Spark Knock Recall Notice
#11
Blue,
I spoke to the service writer after I received a card from them. The card said that the manufacturer had previously attempted to notify me, but the inspection had not be performed. I bought the truck as a demo on 12-31-08. It went into service 10-30-08. It is possible that a notice went out to the dealership since I have only owned it a month.
It has the 5.7 hemi 1500 crewcab. It was built in September, 2008 at Warren. I really don't understand this recall because I don't have the paperwork from Chysler. The dealer said that it is software only. Hopefully someone received the notice and can shed more light on the matter. The hand written card looks like it references a 09-004 or-009 inspection is due. That is all that I know.
I spoke to the service writer after I received a card from them. The card said that the manufacturer had previously attempted to notify me, but the inspection had not be performed. I bought the truck as a demo on 12-31-08. It went into service 10-30-08. It is possible that a notice went out to the dealership since I have only owned it a month.
It has the 5.7 hemi 1500 crewcab. It was built in September, 2008 at Warren. I really don't understand this recall because I don't have the paperwork from Chysler. The dealer said that it is software only. Hopefully someone received the notice and can shed more light on the matter. The hand written card looks like it references a 09-004 or-009 inspection is due. That is all that I know.
#13
#14
Dr. Bill, this is the PCM flash that Savage posted about in the vibration thread. Here is what he said:
I agree, it did not cure the slight vibration in my truck either.
WVU pm'd me about this. i figured id reply here so everyone else can know also.
TSB only applies to vehicles built BEFORE 10-3-08.
Some customers may experience:
·
NVH issues while the vehicle is operating in the MDS mode.
· Spark Knock between 1800 to 2500 RPM.
repair is to flash PCM w/ updated software.
second TSB for slightly rough idle, applies to vehicles built BEFORE 10-3-08:
Some customers may complain of the idle quaility after the vehicle is warmed up. This
condition can happen while the vehicle is in park, neutral, drive or reverse with no
additional throttle tip in. A software change has been made to the increase the warm
nominal idle speed from 584 rpm to 648 rpm, which corrects the condition.
If the vehicle owner complains of this issue reprogram the PCM with the new software.
TSB only applies to vehicles built BEFORE 10-3-08.
Some customers may experience:
·
NVH issues while the vehicle is operating in the MDS mode.
· Spark Knock between 1800 to 2500 RPM.
repair is to flash PCM w/ updated software.
second TSB for slightly rough idle, applies to vehicles built BEFORE 10-3-08:
Some customers may complain of the idle quaility after the vehicle is warmed up. This
condition can happen while the vehicle is in park, neutral, drive or reverse with no
additional throttle tip in. A software change has been made to the increase the warm
nominal idle speed from 584 rpm to 648 rpm, which corrects the condition.
If the vehicle owner complains of this issue reprogram the PCM with the new software.
#15